Year of Manufacture *: 2005
Engine Size and Code *: 2.5 2KD-FTV
( Optional ) Scanner Used: Hanatech
( Optional) Fault Codes: None
This Hiace will cut out after start up, but you can keep it going if you keep your foot on the throttle. After about a minute you can take your foot off and it will idle. It does seem a little down on power. Below is a copy of the job notes
Make: Toyota
Model: Hiace
Year: 2005
Engine: 2KD-FTV
Customers complaint: poor idle
- - - - - - - - - - - - - - - - - -
Perform diagnostic scan.
Stored diagnostic trouble codes:-
No relevant DTCs
Check and clean throttle flap
Remove EGR cooler to check EGR operation
EGR sensor voltage
No vacuum 13.7% = 0.70 Volts
13in-hg 82.0% 1.42 Volts
Check starter circuit
Check low pressure fuel supply
Check MAP sensor
Perform tests using Pico scope:
Check fuel pressure sensor against SCV
Check fuel injector current
Check fuel injection compression on live data
Check charging current and voltage
Any help would be great.
Regards
Simon
Message Thread
« Back to index | View thread »