Fiat Dablo Van 1.9 2001 - Runs for 10 seconds then cuts out, codes P0510 & P0252 #
Posted by Patrick Heaher on December 5, 2010, 11:02 am
Year of Manufacture *: 2001 Engine Size and Code *: 1.9 n/a diesel code 223a6000 ( Optional ) Scanner Used: solus pro ( Optional) Fault Codes: p0510/p0252
engine starts fine and runs for 10 seconds then cuts out ,restarts immediately and same again ; if you start with half throttle the engine light goes out and it will idle for 20-30 seconds then cut as though the ign switched off
the codes are P0510flow modification throttle and P0252 rotor position check
someone suggested egr or airflow meter but im thinking tps any ideas gents
Re: fiat doblo van
Posted by Mark Carter on December 5, 2010, 11:30 am, in reply to "fiat doblo van" Mark Carter
Hi Pat, What tests have you carried out with regard to the ECU fault codes?
Regards MarkModern cars, Its all wizardry and witchcraft
Re: fiat doblo van
Posted by Ian Baxter on December 5, 2010, 12:32 pm, in reply to "fiat doblo van"
Hello Patrick, I have some of these Doblo's in our fleet, And one for the workshop. I take it this is a non turbo using the Lucas Epic System. The flow modification, I wouldn't worry about that, (Fiats line on this code is, if no drive ability problems ignore), we see this on all these vans. The rotor position refers to pump (These are still fairly expensive from Fiat and Fiat exchange units look poor quality so I fit New About £200 more or get original repaired ) or timing belt (only had this problem once after someone tried a tow start in reverse!)or even ECU (these Lucas ECU's can be swapped with no programming required. As for the air pressure sensor, on intake pipe between air filter and inlet manifold, these engines still run ok even when these are broken (metal rod on flap link). But first I would check EGR and see if it has been blanked off, if not then try blanking it off or disconnect wiring for EGR and see if it runs, if you disconnect wiring this will flag up an additional code. These are only suggestions, Don't forget fuses and loose fuses as the terminals in fuse boxes are a little low rent! Plus blocked fuel filters/water in diesel etc etc. (Its a Fix It Again Tomorrow FIAT) HTH, Ian
Re: fiat doblo van
Posted by patrick heaher on December 5, 2010, 5:52 pm, in reply to "Re: fiat doblo van" Patrick Heaher
thanks for that will check and see it seems more like electrical stop ??
Re: fiat doblo van
Posted by Ian Baxter on December 9, 2010, 8:35 pm, in reply to "Re: fiat doblo van"
Hello Patrick, One thought after we spoke earlier today, there is also a fuel cut saftey switch in drivers footwell behind a cut out on plastic trim panel on A pillar. Good luck. Have fun Ian.
on December 5, 2010, 11:30 am, in reply to "
. 
. 
!)or even ECU (these Lucas ECU's can be swapped with no programming required.
FIAT
